case

  1. F

    Trans Transmission and transfer case

    I have 1978 cj5 V8 with the T150 transmission and a Model 20 transfer case. I was checking the fluid levels and noticed the trans was low on fluid and the transfer case was overfilled. I have been around cars long enough to know how to fill both and what level they should be at. Is there a way...
  2. CJ

    1972 Jeep CJ 5 Transfer Case Factory Manual Chapter 8

    1972 Jeep CJ 5 Transfer Case Factory Manual Chapter 8
  3. C

    TCase Dana 20 reversed shift pattern

    Evening All, I’ve got a 76 CJ7, Chevy 350, 400 automatic transmission, Dana 20 transfer case (output case IS magnetic)… here’s my problem. previous owner states (twice) transfer case shift pattern is - front to back: 2h, Neu, 4H, 4L. I haven’t been able to put it up on jack stands yet to...
  4. GreyfoxVt

    NP231 Slip Yoke Eliinator (SYE) Install

    Blowing a rear driveshaft on a stock Jeep is fairly common and can ruin your wheeling weekend. The slip-yoke design on most NP231 transfer cases means that once you remove the driveshaft slip yoke out of the case and try to drive away, all the fluid will come pouring out the seal. In addition...
  5. D

    swapping speedometer gear for T18 Transfer case

    I changed the axles in my M38 A1 from 5:38 to 4:27. The speedometer is now reading too low. Is there another gear set that can be used to help correct this problem?
  6. J

    Transfer case shift knob

    Morning all (LG on the left coast especially since you ALWAYS reply!) Purchased new shift knobs for my 81 CJ 5... Discovered that the transmission one screwed on as advertised, but the screw on one for the transfer case (ordered per the year in the catalog) is actually a press on and a much...
  7. J

    Transfer case shift knob

  8. 7

    Which Transmission and Transfer Case do I have?

    I bought my first Jeep and my first 4wd vehicle yesterday, a 77 CJ with a 3 speed manual and 360 AMC motor. Very fun. I'd like to put twin stick transfer case levers in it, but I don't know exactly what transmission/transfer case I have. I don't want to assume anything. I do all my own work...
  9. 7

    Which Transmission and Transfer Case do I have?

  10. J

    Transmission/Transfer case mount

    Ok Braintrust...here’s today’s issue! Noticed excessive vibration/movement in transmission under load. Was hoping to find a broken engine/transmission mounts... Instead found a trans to mounting plate issue... Mount was loose, but it DOES NOT line up properly with the rear...
  11. J

    Transmission/Transfer case mount

  12. G

    Dana 200 transfer case cant find 2 high

    Looking for the shift rod positions for 2 high, I find 4 high all the way forward but when a pull to what should be 2 high I have nothing then pull to neutral and then down to 4 low which works as does 4 high but nothing for 2 high any thoughts?
  13. G

    Dana 200 transfer case cant find 2 high

  14. M

    Transfer Case Issue? Only Two Positions

    Greetings and please bear with me, this is my first Jeep. Purchased today, a 1969 CJ5. Single lever for the transfer case but there seems to be only two active positions, all the way forward (two wheel “high”) and all the way back (four wheel low). There does not feel like there are any other...
  15. M

    Transfer Case Issue? Only Two Positions

  16. L

    transfer case output shaft seal

    So I'm replacing the seal on the front output shaft. As I'm taking stuff apart, I am noticing silicone behind the shaft nut and on the splines. I am assuming this was done to prevent seeping of oil through the spines. Do you think this is necessary? I have seen this done in other applications...
  17. L

    transfer case output shaft seal

  18. B

    What is the worth of a basket case?

    Hello All, Need a lil insight on what a 1981 CJ5 is worth in a total basket case. Had a 304 from the factory but was scrapped due to cracks. Was going to put a 5.7 chevy in it but have lost interest and have other projects that I want to get to. The Jeep is mostly disassembled and needs a lot of...
  19. M

    Which Transmission and Transfer Case?

    Hello, Longtime admirer but first time owner of a Jeep CJ7. I jumped in the deep end over the weekend and bought a real nice rolling project but no motor/transmission/transfer case. I need advice on which transmission and transfer case would have been stock in a 1980 CJ7. The VIN decodes to...
  20. M

    Which Transmission and Transfer Case?

Back
Top Bottom
AdBlock Detected

I get it, I'm a Jeep owner and ad-block detectors kinda stink but ads are needed on this site. This is a CJ site, all the ads are set for autos (some times others get through.) I cannot make them just for Jeeps but I try.

Please allow ads as they help keep this site running by offsetting the costs of software and server fees.
Clicking on No Thanks will temporarily disable this message.
I've Disabled AdBlock    No Thanks